SlowBro
Florida
Senior Member
Joined: 01/18/2015
View Profile
Good Sam RV Club Member
Offline
|
Our AC duct(s) are leaking cold air into the roof. I pulled the shroud around the bathroom roof vent which exposed the gap between the roof and the ceiling. When I did that could feel plenty of cool air blowing.
Is there an easy way to resolve this or would I need to rip open the ceiling? Maybe like spray something inside?
2010 Coachmen Mirada 34BH, class A, 34.75' long, GVWR 22,000 lbs.
2005 Fleetwood Resort TNT 25QB, hybrid, 27.5' long, GVWR 6,600 lbs.
God bless!
|
prichardson
Lafayette, La
Senior Member
Joined: 10/31/2006
View Profile
Offline
|
Most likely the ducts were not sealed properly at the A/C unit and/or the various registers. To check the unit connections you need to drop the ceiling assy. of the unit. To check the registers; generally the louvered portion pops out. Any gaps in the connections can be sealed with metallic duct tape available at HVAC or plumbing supply houses.
|
SlowBro
Florida
Senior Member
Joined: 01/18/2015
View Profile
Good Sam RV Club Member
Offline
|
The gaps can be sealed from the inside? How would I reach them? Or do I need to cut into the ceiling?
* This post was
edited 09/24/23 03:54am by SlowBro *
|
prichardson
Lafayette, La
Senior Member
Joined: 10/31/2006
View Profile
Offline
|
Most ceiling registers used in RVs have a louvered section that will come out. Once that is removed you will be able to see where the assembly attaches to the duct work. That is where it is often not sealed well.
|
opnspaces
San Diego Ca
Senior Member
Joined: 12/22/2004
View Profile
Offline
|
Before cutting the ceiling buy some HVAC tape at Lowes, Home Depot, ACE or wherever. This is not standard dollar a roll Duct tape. Here's a link to Home Depot.
Link
Pull every register down and carefully seal the gap between the ceiling and the duct. Then pull the inside cover off the AC and seal up all the gaps you see. Then see if there is an improvement.
2001 Suburban 4x4. 6.0L, 4.10 3/4 ton
2005 Jayco Jay Flight 27BH
1986 Coleman Columbia Popup.
|
|
ktmrfs
Portland, Oregon
Senior Member
Joined: 06/22/2005
View Profile
Offline
|
just use aluminum hvac tape and use it to both seal the gap and pull the duct down even with the ceiling.
what you found is a pretty common problem with RV HVAC systems
2011 Keystone Outback 295RE
2004 14' bikehauler with full living quarters
2015.5 Denali 4x4 CC/SB Duramax/Allison
2004.5 Silverado 4x4 CC/SB Duramax/Allison passed on to our Son!
|